Investigation of the Newtonian fluids flow in circular horizontal tubes at low inlet pressures

The issues of increasing hydrodynamic efficiency, improving the operational and technical characteristics of various apparatus and devices used in the fi eld of heat and mass transfer, as well as ensuring the required regime and flowow conditions of liquids of different viscosities do not lose their relevance. To solve these issues, in addition to studying the nature of the flowow of various liquids in round horizontal tubes (capillaries), it is necessary to determine the conditions when the flowow of liquid in capillaries and round tubes of small diameter is laminar and can be described by the Poiseuille equation. Experimental data on determining water flow ow through horizontal round tubes of various diameters are presented. Determining the patterns and features of such flow ows is mostly aimed at increasing hydrodynamic efficiency, improving the operational and technical characteristics of various apparatus and devices, as well as ensuring the required flow ow regime and conditions. Experimental data on determining the flow ow rate of water through horizontal tubes of circular cross-section with different diameters are presented in the article. The dependence of the volumetric flow ow rate on the pressure drop has been determined; it has been shown that the main parameters that determine the nature of the flow ow of liquids in horizontal tubes are the tube radius and the dynamic viscosity of the liquid. The flow ow of distilled water in tubes with diameters of 0.95, 1.6 and 2.0 mm at an overpressure of 0.266 kPa to 4 kPa is considered. It is shown that the dependence of the volumetric flow ow rate on the excess pressure remains linear at 0.95 mm in the entire considered pressure range. An increase in the tube radius increases the likelihood of velocity flow uctuations and the appearance of a radial velocity component, i.e. the occurrence of elements of a turbulent structure. In this regard, with tube diameters of 1.6 and 2.0 mm, a deviation of the water flow ow regime from the laminar character was established at pressures of more than 1.3 kPa and 1 kPa, respectively. The dependence of the volumetric flow ow rate on pressure for a 40 % aqueous solution of CaCl2, transformer, transmission and engine oils with dynamic viscosity coefficients from 0.002 Pa·s to 0.182 Pa·s remains linear up to pipe diameters of 5–6 mm. The experimental results are shown in the form of a nomogram of the dependence of the coefficient K* on the tube radius at different values of the viscosity coefficient. The results of studies of liquids of various viscosities are presented in the form of a nomogram of the dependence of the ratio of the radius of the tube to the fourth power to the viscosity of the liquid on the radius of the tube. The analysis of which makes it possible to predict the nature of the flow ow of the investigated liquid at the given values of the tube radius and the dynamic viscosity coefficient. Heat exchange devices for the design of which the presented results can be used include a variety of radiators that include tubes through which coolant circulates.